WARRANTY
All our vehicles are supplied with a comprehensive parts and labour Vans Direct warranty, which can be extended up to 4 years.
PARTS COVERED
Engine
Failure of the following mechanical parts: Starter ring gear, flywheel,
oil pump, crankshaft and bearings, timing gears and chains (excluding
tensioner and electronic devices) camshafts and bearings, cam
followers, oil cooler, intercooler, tappet gear, valves and guides
(excluding burnt out valves) pistons and rings, cylinder bores, con rods,
Exhaust brake all parts (excluding seizing), core plugs, rear main oil
seal, timings cover oil seal, thrusts & shims. Timing belts are covered
as long as they have been changed in line with the manufacturers
schedules. You will need to be able to provide proof of this.
Cooling System
Failure of the following mechanical parts; Head gasket, thermostat,
cooling fan clutch, water pump, radiator, excluding choked, blocked or
corroded units and all other parts associated with the cooling system.
Manual Transmission
Failure of the following parts: gears, shafts, synchro hubs, selectors,
bearings & bushes, splitter mechanisms, range changes and overdrive
units when fitted (excluding electrics and external linkages). Range
change and splitter valves and solenoids.
Automatic Transmission
Failure of the following: Torque convertor, gears, clutches, brake
bands, valve block, governor, oil pump, bearings and bushes (but
excluding external linkages, adjustments and electrics).
Clutch
(Manual Transmission) Failure of the following parts: Clutch plate,
clutch cover, thrust bearing (excluding external linkages, burnt out
parts and general wear & tear). Limited to one clutch repair during the
period of cover.
Front Wheel Drive
Drive shafts, including constant velocity joints, universal joints and
couplings (excluding gaiters).
Rear Axles
Failure of the following mechanical parts: Crown wheel and pinion,
half shafts, half shaft oil seal and bearings, hub reduction gears,
bearings and two-speed operating mechanisms (excluding external
linkages). Diff locks and mechanism, planetary gears, diff pinion seal.
4 Wheel Drive Vehicles
Cover as above for front and real wheel drive.
Propshafts
Failure of the propshaft including universal joints and bearings.
Electrics
Failure of the following parts: Starter motor, alternator, wiper motor,
relays, electric window motors, tachograph and sender units, buzzers,
horns (including air horns), flasher/headlamp switch (all other parts
are excluded).
Fuel System
Failure of the lift pump and fuel injection pump, EDC units, pump
couplings, excluding injectors, pipes, linkages and all other parts
associated with the fuel system.
Steering
Failure of the following mechanical parts: Steering box, idler box,
power steering unit including pump, pressure pipes and reservoir
(excluding power steering belts, external links and joints, rubber boots
ad swivel pins).
Braking System
Failure of the following mechanical parts: Master cylinder, air control
cylinder and brake actuators, air valves, servo, wheel cylinders and
calipers, ABS valves and sensors and control units, compressor/air
dryer, brake chambers. (All other parts associated with the braking
systems are specifically excluded from this policy).
Turbo Charger
All internal parts.
Engine Management
Engine Electronic control unit.
Suspension
Front and rear levelling valves, load sensor valves, air bags, levelling
control unit for raising and lowering of suspension.
Casings
The following casings are covered provided they have been damaged
by a failure and/or by the consequential damage of the insured parts
failing: Cylinder block, cylinder head, gearbox/transfer casing, rear
axle housing, carrier casing and bell housing (Damage as a result of
accident, frost or overheating is excluded). |
